|
|
|
jack daniels
Sr. Member
Posts: 132
|
|
« Reply #3 on: January 28, 2010, 01:08:39 pm » |
|
Hi Marko, the oil was drained from my DP0-005 just last week, about 3 liters came out. the total capicity of the transmission is 6 liters but only half of that will come out when you remove the drain plug. If you have filled with 5 liters then you'll have 8 liters in there now. I'd reccomend not using the car untill it's drained down to the correct level, better safe than sorry. The problem you describe could be due to too much oil/ incorrect oil pressure now.
when the engine is warm, take out the level plug ( the smallest one ) with the engine idling. At normal engine temperatures the transmission oil will be about the correct temperature.
if you need to add oil you can just pump it thru a tube up the drain tube/ level plug hole if your garage has the right equipment. I guess you know the reccomended oil is Elf Reanultmatic D3 syn.
good luck
|
|
|
Logged
|
Espace, Grand (magnifique, formidable, grandiose, considérable, noble, ample) III 2002 JE02 F4R DP0 2.0L 16v auto
|
|
|
|
|
|
|
|
|
jack daniels
Sr. Member
Posts: 132
|
|
« Reply #10 on: January 29, 2010, 07:59:00 pm » |
|
hei Marko, in response to your PM, I haven't had any trouble with the trans in my espace which has 86000km on the clock now. I guess as long as you change the oil occasionally, say every 2 years at least, and don't tow anything with the car it should be trouble free. It has very smooth gear shifts. there are some documents available with some detail of the trans. http://www.scribd.com/doc/6338026/AL4-Transmission (this is the citroen version of the same unit) http://www.matrasport.dk/Cars/Espace/vault/JE/3219A_JE_F4R.pdfthe filters are visable under the oil pump and in the valve block
|
|
|
Logged
|
Espace, Grand (magnifique, formidable, grandiose, considérable, noble, ample) III 2002 JE02 F4R DP0 2.0L 16v auto
|
|
|
|
|
|
marko ucha
Newbie
Posts: 23
|
|
« Reply #14 on: January 30, 2010, 10:35:49 pm » |
|
At first to much oil..... and after leveling it write..... it needed 2-3 days to start working normally.... I think that extra oil coses same faults in ECU, now all is write and sensors give god informations.... and I saw a leak near flayweal from box.... It start to put it out....but now it is O.K. no damage! Thank you one more time.... I can't survive to take out auto and put manual box.I like my DPO 005 to much Is their something more on what I should pay attention?
|
|
|
Logged
|
Rebault Grand Espace 2.0 16v automatic
|
|
|