| Home  Blogs Help Search Login Register  
« previous next »
Pages: [1] Print
Author Topic: Remote central locking - succesfull resync - still not working  (Read 24194 times)
e.space.3
Jr. Member
**
Posts: 44



« on: October 04, 2011, 10:14:00 am »

Hello

Straight to subject
To put things in order:

1. some time ago the central locking from key (both of them) starts to work intermittently and only from certain angle from the car.

2. I have resynchronized the keys (both) successfully then, like here:
Quote
I. All doors closed, ignition ON then OFF
II. Press the CDLB (in roof console) until doors lock/unlock, Within 15 seconds, complete next steps
II. Press the 1st PLIP once (doors lock/unlock)
IV. Press the 2nd PLIP once (doors lock/unlock)
But  the problem from 1. persisted.

3. Now it doesn't works at all.

4. I tried to repeat the step 2. but this time it didn't work.

5. I used the "mechanical/manual way" to unlock/lock the car from drivers side, and roof console button for rest of the doors.

6. Both keys have a working red LEDs when I press the remote. Should I change the batteries Huh

7. Those things come, in my mind to conclusion there is a problem with in car receiver.
I remembered, I have read somewhere on the Internet, about little circuit that controls the dashboard display of Renault Scenic and Audi TT.
If you heat it for few seconds it will starts magically working.
So this summer when outside were 39 degree Celsius, i have closed the doors and start heating system. When the interior of the car became to hot to breath I have stopped the engine.
I have initiate the resynchronization procedure and it worked.  Shocked
BUT.... the locking/unlocking from key fob, after the inside climate was cooled down, still doesn't work.

8. The unlocking/locking problem is still present today.



Is there a chance to make things works normally again Huh

RESPECT
Logged

1999 JE0N F4R A 700 RXE
BrianM
Sr. Member
****
Posts: 325


« Reply #1 on: October 06, 2011, 11:55:47 am »

I had the same fault. To save time I changed the dash cluster from another car for which I also had the key fob. I will look into the fault with a few more knowlegeable than myself & report back.

pile of clusters to sort out, mostly kms need zeroing
 
I think this is the reciever but swapping it does not make the locking work so think it is on the main board.
Logged
renaultbiler
Sr. Member
****
Posts: 418



WWW
« Reply #2 on: October 07, 2011, 07:49:21 pm »

Either get a new dash unit or send it to bba-reman or similar for repair. You can scratch you head hairfree or something and you still will be struggeling.
Its a motorola chip with poor design that is to blame almost every time problems occur with instrument or BII unit.
Logged

1980 Alpine A-310 w/GTA 2.5 V6 Turbo
2000 Grand Espace V6 24v Initiale: http://www.renaultbiler.no/forum/viewtopic.php?id=2529
2000 Scenic RXi 2.0 16v IDE aut DP0: http://www.renaultbiler.no/forum/viewtopic.php?id=3751
1982 R20TX 2.2
Service Online: www.servicehefte.net/servdata/?cid=qqkX
BrianM
Sr. Member
****
Posts: 325


« Reply #3 on: October 09, 2011, 03:59:32 pm »

I don't think it is the motorola in this case. Yes the 908 is a poor quality chip but it is only active when the ign. is turned on as it needs the relevent clock circuit to work.
Logged
renaultbiler
Sr. Member
****
Posts: 418



WWW
« Reply #4 on: October 10, 2011, 11:21:33 pm »

Ive seen a few of these with faulty remote in addition to other faults with panel, take a hair dryer and heat this chip up and it suddenly works.... Roll Eyes
Logged

1980 Alpine A-310 w/GTA 2.5 V6 Turbo
2000 Grand Espace V6 24v Initiale: http://www.renaultbiler.no/forum/viewtopic.php?id=2529
2000 Scenic RXi 2.0 16v IDE aut DP0: http://www.renaultbiler.no/forum/viewtopic.php?id=3751
1982 R20TX 2.2
Service Online: www.servicehefte.net/servdata/?cid=qqkX
e.space.3
Jr. Member
**
Posts: 44



« Reply #5 on: October 14, 2011, 07:26:55 am »

Thanks for your responses

Ive seen a few of these with faulty remote in addition to other faults with panel, take a hair dryer and heat this chip up and it suddenly works.... Roll Eyes


Already done that. Almost the same, only I don't disassembled the dashboard and used the heating system of the car.

It is obvious this will not work, when you are outside of the car, with feet stuck in the snow, trying to open doors from key fob.  Grin

@renaultbiler
The complete name is MC68HC908AZ60?

Is this the only problem Huh
Cause I can manage to change the chip.



RESPECT
« Last Edit: October 14, 2011, 09:06:51 am by e.space.3 » Logged

1999 JE0N F4R A 700 RXE
renaultbiler
Sr. Member
****
Posts: 418



WWW
« Reply #6 on: October 14, 2011, 07:15:49 pm »

Ive never repaired these myself, so i dont know if its possible to replace the chip without any software transplant.

I replaced instrument panel on one a few years ago, the owner had fitted a 1.2w bulb on top of this chip to keep it warm and working for a good while Roll Eyes Pretty creative - and effective for a year or two.
Logged

1980 Alpine A-310 w/GTA 2.5 V6 Turbo
2000 Grand Espace V6 24v Initiale: http://www.renaultbiler.no/forum/viewtopic.php?id=2529
2000 Scenic RXi 2.0 16v IDE aut DP0: http://www.renaultbiler.no/forum/viewtopic.php?id=3751
1982 R20TX 2.2
Service Online: www.servicehefte.net/servdata/?cid=qqkX
Pages: [1] Print 
« previous next »
Jump to: